Becker Mexico CD Player BMW 5 Series (E34)

EBA – 01 29 9 781 687
BMW Installation Instructions
Becker Mexico CD Player BMW 5 Series (E34)

Note:

These installation instructions supplement the existing in­ stallation instructions “HiFi system without CD player, BMW 5 Series (E34)” (Order No. 01 29 9 781 518).

lnstructions and illustrations are given here for left-hand­ drive cars. On right-hand-drive cars various werk stages must be carried out on the opposite side or in mirror-image fashion .

Additional tools and materlals required:

Ring wrench, 7 mm across flats
Hammer
Drift, 6 mm diameter

Section 6

See Fig. No. F 34 65 010 (page 6 of German instructions).

Only install the additional wiring harness from the radio cutout.

The instailation procedure for the aerial lead is different: separate instructions are given below.

F 34 65 047

Becker Mexico CD Player BMW 5 Series (E34)

Sectlons 7 and 9 are not appllcable. Open the glove box.

Push out retaining pins (1,2) as indicated by the arrows, and detach the retaining straps.

F 34 64 056

Becker Mexico CD Player BMW 5 Series (E34)

Pull levers (1) in the direction of the arrows and remove the glove box.

F 34 64 057

Becker Mexico CD Player BMW 5 Series (E34)

Take out Phillips screws (1) and pull out trim (2) as indicated by the arrow.

F 30 52 058

Becker Mexico CD Player BMW 5 Series (E34)

See Fig. No. F 30 52 058 (page 8 of German instructions). Lever out front and rear cover trims (1) on both sides of the car.

F 34 65 021

Becker Mexico CD Player BMW 5 Series (E34)

See Fig. No. F 34 65 021 (page 9 of German instructions). Fold back the carpet on the left and the right at the rear seat base. Remove four spreader rivets (1) and take off plastic cover (2).

F 34 65 193

Becker Mexico CD Player BMW 5 Series (E34)

Sectlon 10

From Fig. No. F 32 65 026 onwards (page 10 of German instructions)

Run connecting wire (1) from the CD player instailation point to the rear seat base on the right as illustrated.

F 34 65 186

Becker Mexico CD Player BMW 5 Series (E34)

Insert aerial lead (1) in the cable retainers along the rear shelf and run to the rear seat base on the right.

lnstall the aerial amplifier according to the separate installa­ tion instructions.

F 34 65 194

Becker Mexico CD Player BMW 5 Series (E34)

Run additional wiring harness (1) to rubber grommet (2) on the right-hand side of the rear bulkhead.

Secure additional wiring harness (1) in existing cable straps (3).

F 34 65 162

Becker Mexico CD Player BMW 5 Series (E34)

Section 11

From Fig. No. F 32 65 018 onwards.

Rotate slotted screws (1) in right luggage compartment trim

(2) through 90 degrees as indicated by the arrows and remove luggage compartment trim (2). Take out the wheel check and the car jack . Remove luggage compartment trim (3).

F 34 65 195

Becker Mexico CD Player BMW 5 Series (E34)

Lever rubber grommet (1) out of rear bulkhead (2). Cut out sections (3,4).

Insert the connecting wire (5) and aerial lead (6) in cutout (3). Insert additional wiring harness (7) in cutout (4).

F 34 65 196

Becker Mexico CD Player BMW 5 Series (E34)

Run connecting wire (1), aerial lead (2) and additional wiring harness (3) into the luggage compartment as illustrated. Insert the rubber grommet into the rear bulkhead.

F 34 65 197

Becker Mexico CD Player BMW 5 Series (E34)

Section 12

From Fig. No. F 34 65 073 onwards

Insert retainers (1) on receiver stage (2) into the slots on holder (3).

Secure receiver stage (2) with M5 x 10 hex bolt (4) and washer (5).

F 34 65 198

Becker Mexico CD Player BMW 5 Series (E34)

Push aerial lead (1) and connecting wire (2) on to receiver stage (3) as illustrated.

Connect white front loudspeaker plug (4) and black rear loudspeaker plug (5) to receiver stage (3) according to the in­ scriptions on the tags.

Connect combination plug (6) and cable plug (7) to receiver stage (3) as illustrated.

F 34 65 199

Becker Mexico CD Player BMW 5 Series (E34)

lnstall all connecting cables as shown in the drawing and secure with cable straps (1) at the holes in holder (2).

F 34 65 200

Becker Mexico CD Player BMW 5 Series (E34)

Fit sheet-metal nuts (1) on to holder (2).

F 34 65 201

Becker Mexico CD Player BMW 5 Series (E34)

lnstall holder (1) as illustrated.

Insert Phillips screws (2) and tighten .

F 34 65 181

Becker Mexico CD Player BMW 5 Series (E34)

Section 13

See Fig. No. F 34 65 085 (page 15 of German in­ structions)

On cars without special equipment , the loudspeaker cable must be retrofitted by carrying out the foilowing work steps. Take out hex bolts (1).

F 34 65 182

Becker Mexico CD Player BMW 5 Series (E34)

Pull off spring keeper (1). Knock out pin (2).

F 34 65 183

Becker Mexico CD Player BMW 5 Series (E34)

Lift compact plug (1) out of A-post (2). Pull retainer (3) in the direction of the arrow and litt out cable plug (4).

F 34 64 184

Becker Mexico CD Player BMW 5 Series (E34)

Insert cable plug (1) (yellow/brown wire) from adapter cable

(2) at connecting point 25 of the door wiring harness. Insert cable plug (3) (yellow/white wire) from adapter cable

(2) at connecting point 26 of the door wiring harness.

F 34 65 185

Becker Mexico CD Player BMW 5 Series (E34)

Pull adapter cable (1) into door wiring harness (2) as il­ lustrated and run to mirror triangle (3).

lnstall door wiring harness by carrying out the removal pro­ cedure in the reverse order .

F 34 65 202

Becker Mexico CD Player BMW 5 Series (E34)

Section 15

Fit clips (1) as illustrated and insert spacer frame (2).

F 32 65 537

Becker Mexico CD Player BMW 5 Series (E34)

Screw pin (1) on to the CD player.

Plug connecting wire (2) on to the CD player as shown by the drawing.

F 32 65 538

Becker Mexico CD Player BMW 5 Series (E34)

Push combination plug (1) from the additional wiring harness on to the CD player.

Connect blue cable plug (2) from the additional wiring harness to the mating plug on the CD player.

Push the CD player into the radio cutout until catches (3) on the CD player lock into position.

lnstall all the dismantled parts by carrying out the removal procedure in reverse order .

Check that the CD player functions correctly (refer to CD player operating instructions).

F 32 65 540

Becker Mexico CD Player BMW 5 Series (E34)

To remove the CD player, lf required:

Disconnect the car battery.

Carefully lever trim (1) off the CD player retaining clips (2) as illustrated.

F 32 65 192

Becker Mexico CD Player BMW 5 Series (E34)

Insert release hooks (1) into locks (2) as shown by the draw­ ing and rotate in the direction of the arrows.

Carefully pull out the CD player.

Printing and other errors and omissions excepted. Subject to amendment.

banner